Dole Fresh Vegetables is recalled bagged salad product due to the potential to be contaminated with Listeria. The issue was discovered after the Canadian Food Inspection Agency (CFIA) found Listeria in a single random sample of product. The limited number of cases were shipped to 15 different states and 3 Canadian provinces. No illnesses have been reported.
FDA Recall Notice
http://www.fda.gov/Safety/Recalls/ucm389296.htm
Dole Fresh Vegetables Voluntarily Recalls Limited Number of Bagged Salads Due to Possible Health Risk
Contact:
Consumer:
800-356-3111
Media:
William Goldfield
818-874-4647
William.Goldfield@Dole.com
FOR IMMEDIATE RELEASE - March 13, 2014 - Dole Fresh Vegetables is voluntarily recalling a limited number of cases of bagged salad. The products being recalled are Dole Italian Blend (UPC 7143000819), Fresh Selections Italian Style Blend (UPC 1111091045), Little Salad Bar Italian Salad (UPC 4149811014) and Marketside Italian Style Salad (UPC 8113102780) coded A058201A or B, with Use-by date of March 12, 2014 due to a possible health risk from Listeria monocytogenes. Dole Fresh Vegetables is coordinating closely with regulatory officials. No illnesses have been reported in association with the recall.
The product code and Use-by date are in the upper right-hand corner of the package; the UPC code is on the back of the package, below the barcode. The salads were distributed in 15 U.S. states (Connecticut, Florida, Illinois, Indiana, Kentucky, Maryland, Massachusetts, Michigan, New Jersey, New York, North Carolina, Ohio, Pennsylvania, South Carolina, Virginia) and 3 Canadian provinces (New Brunswick, Ontario & Quebec).
Friday, March 14, 2014
Wednesday, March 12, 2014
FDA Shuts Down Delaware Cheese Plant
FDA shut down the Roos Foods cheese plant, that had recently recalled product linked to a Listeria outbreak, after FDA found a number of findings in their investigation.
From the FDA report, the findings included:
The conditions found in the inspection were sure issues for Listeria contamination....leaks contributing to excessive moisture into the processing environment and being a source of contamination, poor cleaning practices that allow for growth of Listeria within that environment, poor operating equipment that allows access of that contamination to the product, and finally the facility was in bad condition which prevented that contamination from being removed. The
In short, Listeria contamination had access into the facility and to the product, the conditions within the plant supported growth of the organism and bad facility conditions prevented good cleanup.
It is also important to note that this is the second time that FDA used its new powers granted by FSMA to remove a facilities registration and thus shut down that facility. The first case was the peanut butter facility that had Salmonella contamination. After about a number of months of working with FDA, that peanut butter facility ended up closing for good. If this is an indication, this cheese facility will have a long road to get to the point of reopening, if they survive at all.
.
FDA News Release
From the FDA report, the findings included:
- the roof leaking so badly that water was raining down into the cheese processing room, including onto the cheese processing equipment and storage tanks;
- standing water on the floor throughout the cheese curd processing room in proximity to the cheese vats and in the storage rooms;
- metal roof/ceiling and metal supports exhibiting a rusted appearance with metal flaking precluding effective cleaning and sanitizing;
- food residues found on equipment after cleaning had been performed;
- openings to milk storage tanks and transfer piping were not capped to prevent contaminants from entering or contaminating food contact surfaces; and
- floors, wall, and equipment that were deteriorated and in bad repair, including processing equipment and storage vats with rust holes and floors with rough concrete deterioration.
.
FDA News Release
FDA Investigates presence of Listeria in some Hispanic-style Cheeses
UPDATE
The FDA suspended the food facility registration of Roos Foods Inc.2 of Kenton Delaware on March 11, 2014 after the FDA determined there was a reasonable probability of food manufactured, processed, packed, or held by Roos Foods causing serious adverse health consequences or death to humans.
The FDA ordered the suspension after an investigation by the FDA, Centers for Disease Control and Prevention, and state and local partners linked a multi-state outbreak of listeriosis to cheeses found to be contaminated with Listeria monocytogenes and manufactured by the company. Food facility registration is required for any facility engaged in manufacturing, processing, packing, or holding food for consumption in the United States, and if the registration of a facility is suspended, no person shall introduce food from such facility into interstate or intrastate commerce in the United States. The FDA inspected the company’s facility from February 18 – March 4, 2014. During the inspection, FDA investigators found insanitary conditions including:
- the roof leaking so badly that water was raining down into the cheese processing room, including onto the cheese processing equipment and storage tanks;
- standing water on the floor throughout the cheese curd processing room in proximity to the cheese vats and in the storage rooms;
- metal roof/ceiling and metal supports exhibiting a rusted appearance with metal flaking precluding effective cleaning and sanitizing;
- food residues found on equipment after cleaning had been performed;
- openings to milk storage tanks and transfer piping were not capped to prevent contaminants from entering or contaminating food contact surfaces; and
- floors, wall, and equipment that were deteriorated and in bad repair, including processing equipment and storage vats with rust holes and floors with rough concrete deterioration.
Additionally, the FDA collected environmental samples from different areas of the facility, including the cheese processing room and various pieces of equipment. FDA's testing identified 12 swabs that tested positive for Listeria monocytogenes, and pulsed-field gel electrophoresis (PFGE) analysis showed that 11 of those swabs had the same Listeria monocytogenes "DNA-fingerprint" as the outbreak strain.
In response to evidence collected during the investigation by the FDA, CDC, and state officials, the state of Delaware’s Division of Public Health issued a Cease and Desist Production and Distribution order to the firm on February 28, 2014.
The FDA will vacate the suspension order and reinstate Roos Foods’ facility registration when the FDA determines that food manufactured, processed, packed, or held at the facility no longer has a reasonable probability of causing serious adverse health consequences or death to humans.
Monday, March 10, 2014
Canned and Frozen Fruits and Vegetables - Cost Effective Nutrition
When you hear anything on proper nutrition, fresh fruit and vegetables are always part of that message. But for many, fresh produce is not always available, or affordable. But what about canned and frozen produce? A recent study shows that canned and frozen are a nutritious and cost effective option, and need to be included in the choices for those families looking to prepare healthy meals.
Are there downsides - sure, some canned foods may have higher sodium levels. There are also impacts on some of the heat sensitive vitamins and other bioactive components....but these will also be impacted by the consumer's handling and preparation practices. However, in a world where the food dollar does not go as far, and we look to become more sustainable, canned and frozen produce are important options.
Medical Daily
Canned Fruits And Vegetables May Be As Nutritious As Their Fresh Counterparts
By Matthew Mientka | Mar 8, 2014 01:30 PM EDT
http://www.medicaldaily.com/canned-fruits-and-vegetables-may-be-nutritious-their-fresh-counterparts-270793
No one can deny the beauty of the native tomato. Yet in feeding a hungry world, canned fruits and vegetables are just as good as fresh or frozen produce, and in some cases even better, according to a new study.
Researchers at Michigan State University found that canned tomatoes deliver more B vitamins as well as lycopene, a carotene loosely tied to a lowered cancer risk. The canning process also makes fiber more soluble in vegetables such as beans, providing a value-added for the food staple.
Canned vegetables offer consumers a more affordable option at 20 percent of the cost of fresh vegetables — and half as much as frozen.
“Canned fruits and vegetables provide high quality nutrition to Americans regardless of income level and geography,” researcher Steven Miller said in a statement. “By increasing accessibility to key nutrients many Americans need, canned foods are a year-round solution to help families prepare healthier, balanced meals.”
Are there downsides - sure, some canned foods may have higher sodium levels. There are also impacts on some of the heat sensitive vitamins and other bioactive components....but these will also be impacted by the consumer's handling and preparation practices. However, in a world where the food dollar does not go as far, and we look to become more sustainable, canned and frozen produce are important options.
Medical Daily
Canned Fruits And Vegetables May Be As Nutritious As Their Fresh Counterparts
By Matthew Mientka | Mar 8, 2014 01:30 PM EDT
http://www.medicaldaily.com/canned-fruits-and-vegetables-may-be-nutritious-their-fresh-counterparts-270793
No one can deny the beauty of the native tomato. Yet in feeding a hungry world, canned fruits and vegetables are just as good as fresh or frozen produce, and in some cases even better, according to a new study.
Researchers at Michigan State University found that canned tomatoes deliver more B vitamins as well as lycopene, a carotene loosely tied to a lowered cancer risk. The canning process also makes fiber more soluble in vegetables such as beans, providing a value-added for the food staple.
Canned vegetables offer consumers a more affordable option at 20 percent of the cost of fresh vegetables — and half as much as frozen.
“Canned fruits and vegetables provide high quality nutrition to Americans regardless of income level and geography,” researcher Steven Miller said in a statement. “By increasing accessibility to key nutrients many Americans need, canned foods are a year-round solution to help families prepare healthier, balanced meals.”
Is Produce Safe from Pesticides? USDA Releases Pesticide Residue Testing Data
The USDA released its annual pesticide residue testing data http://www.ams.usda.gov/AMSv1.0/getfile?dDocName=stelprdc5106521 for 2012. In the report, over 99% of the products sampled had results that were within EPA tolerances.
So traditional produce purchased from your supermarket is safe (extremely low risk). Of course, there are those who will continue to pay more for 'organic'. Is it worth the added price? This data suggests it is not.
One issue I have is that USDA should provide a discussion of 'out of tolerance' samples in their report rather than just glossing it over. They did issue "What Consumer Should Know".
Of course, 99.47% is not 100%, and there were a few samples that were above the established tolerance. From a blog by Steve Savage who took the time to analyze the few high results.
The only crops with any significant number of above-tolerance detections were snap peas (32 from among 743 samples) and cherry tomatoes (24 from among 744 samples). However, even these unusual incidences were not enough above tolerance to be of major concern. For the snap peas, 97% of the samples with those higher detections were imported either from Guatemala, Peru or Mexico. For the cherry tomatoes, 83% of the above-tolerance samples came from Mexico. If the "group project" was divided into a US farmers team and a importers team, their respective "scores" would be 99.88% and 98.76% - different, but both still A+ grades.It is important to note that the tolerance levels that are set have a 100X or so safety factor.
So traditional produce purchased from your supermarket is safe (extremely low risk). Of course, there are those who will continue to pay more for 'organic'. Is it worth the added price? This data suggests it is not.
One issue I have is that USDA should provide a discussion of 'out of tolerance' samples in their report rather than just glossing it over. They did issue "What Consumer Should Know".
What Consumers Should Know
2012 Pesticide Data Program Annual Summary
- This PDP data shows that overall pesticide residues found on foods tested are at levels below the tolerances established by the U.S. Environmental Protection Agency (EPA) and pose no safety concern.
- Each year, USDA and EPA work together to identify foods to be tested on a rotating basis. In 2012, surveys were conducted on a variety of foods including fresh and processed fruits and vegetables, wheat, butter, baby food, and water.
- PDP data reflect actual residues present in food grown in various regions of the U.S. and overseas.
- EPA makes a safety evaluation for pesticides considering all possible routes of exposure through food, water, and home environments when setting the maximum residue (tolerance) level of pesticide that can remain in or on foods.
- Before a pesticide is available for use in the U.S., the EPA must determine that it will not pose unreasonable risks to human health or the environment.
Friday, March 7, 2014
Alton Brown with Food Safety Tips in the Kitchen
While food celebrity Alton Brown is big proponent of food safety in the kitchen, his Today Show presentation melds the lines between food spoilage and food safety. Granted, we do not want to eat food that is spoiled, but that does not necessarily indicate that food pathogens are present. And food can look and smell good, and even taste normal, and still contain pathogens that can make you ill. So it is important to rely on safe handling and storage procedures to keep food safe.
Regardless, Alton gives a number of helpful hints for safely storing and handling food in the video clip.
Today
Smelly, sticky or slimy? Food safety rules you shouldn't ignore
Linda Carroll TODAY contributor
March 5, 2014 at 11:17 AM ET
http://www.today.com/health/smelly-sticky-or-slimy-food-safety-rules-you-shouldnt-ignore-2D79321828#
When it comes to figuring out whether the food in your cupboards and fridge are spoiled, it’s best to trust your gut.
Your eyes, nose and fingers can tell you if food has spoiled, according to Alton Brown, host of the Food Network’s “Cutthroat Kitchen.”
“We all have the senses to know when food has gone bad,” Brown said. “Smell it. If it smells bad, odds are you shouldn’t eat it. Touch it. If it’s slimy or sticky, don’t eat it. If you look at a piece of meat and it’s got splotches of green on it, you shouldn’t eat it.”
Each year one in six Americans gets sick from eating contaminated food. The best way to avoid becoming one of those stats is to take care in how you store and handle your food — and trust your senses.
Foods will last longest in a refrigerator kept below 40 degrees F. But many refrigerators aren't as cold as they need to be, even at the lowest setting. Invest in a thermometer so you know it really is cold enough.
How you pack your foods in the fridge makes a difference, too.
“Stack it so you’re keeping the foods that could be dangerous away from everything else,” Brown said.
Place meats in the bottom compartments. Meats produce a lot of fluid and you don’t want those juices to drip onto cooked foods or veggies and fruits contaminating them. Beyond that, in most refrigerators, the lowest temperatures are in the bottom shelves.
Store fish on ice, even if it’s in the refrigerator. That’s because fish goes bad faster than any other meat.
Eggs be stored in the meat compartments rather than on the shelves in the door.
The biggest danger in your refrigerator is from contamination. “This may sound odd, but contaminated food will make you sick, but spoiled foods won’t necessarily make you sick,” Brown said.
When it comes to fruits and veggies, it’s OK to store them in the plastic bags you packed them up in at the store.
To keep them freshest, Brown suggests packing a paper towel in the bag before putting it into to the fridge. The towel will absorb any moisture from produce respiration.
When it comes to thawing meats, whenever possible it should be done in the refrigerator, Brown said. And put them in a plastic container so they don’t drip all over everything eIse.
If you need a quick thaw then put the meat in a plastic bag in the sink and run a thin stream of cold water over it.
Another important tip: Always wipe down food preparation surfaces. Brown suggests using a solution of ¼ teaspoon of bleach in a cup of water.
And when you’re prepping fruits and veggies always rinse with cold water. If the surface is bumpy, then use a brush to get them clean, Brown said.
Regardless, Alton gives a number of helpful hints for safely storing and handling food in the video clip.
Today
Smelly, sticky or slimy? Food safety rules you shouldn't ignore
Linda Carroll TODAY contributor
March 5, 2014 at 11:17 AM ET
http://www.today.com/health/smelly-sticky-or-slimy-food-safety-rules-you-shouldnt-ignore-2D79321828#
When it comes to figuring out whether the food in your cupboards and fridge are spoiled, it’s best to trust your gut.
Your eyes, nose and fingers can tell you if food has spoiled, according to Alton Brown, host of the Food Network’s “Cutthroat Kitchen.”
“We all have the senses to know when food has gone bad,” Brown said. “Smell it. If it smells bad, odds are you shouldn’t eat it. Touch it. If it’s slimy or sticky, don’t eat it. If you look at a piece of meat and it’s got splotches of green on it, you shouldn’t eat it.”
Each year one in six Americans gets sick from eating contaminated food. The best way to avoid becoming one of those stats is to take care in how you store and handle your food — and trust your senses.
Foods will last longest in a refrigerator kept below 40 degrees F. But many refrigerators aren't as cold as they need to be, even at the lowest setting. Invest in a thermometer so you know it really is cold enough.
How you pack your foods in the fridge makes a difference, too.
“Stack it so you’re keeping the foods that could be dangerous away from everything else,” Brown said.
Place meats in the bottom compartments. Meats produce a lot of fluid and you don’t want those juices to drip onto cooked foods or veggies and fruits contaminating them. Beyond that, in most refrigerators, the lowest temperatures are in the bottom shelves.
Store fish on ice, even if it’s in the refrigerator. That’s because fish goes bad faster than any other meat.
Eggs be stored in the meat compartments rather than on the shelves in the door.
The biggest danger in your refrigerator is from contamination. “This may sound odd, but contaminated food will make you sick, but spoiled foods won’t necessarily make you sick,” Brown said.
When it comes to fruits and veggies, it’s OK to store them in the plastic bags you packed them up in at the store.
To keep them freshest, Brown suggests packing a paper towel in the bag before putting it into to the fridge. The towel will absorb any moisture from produce respiration.
When it comes to thawing meats, whenever possible it should be done in the refrigerator, Brown said. And put them in a plastic container so they don’t drip all over everything eIse.
If you need a quick thaw then put the meat in a plastic bag in the sink and run a thin stream of cold water over it.
Another important tip: Always wipe down food preparation surfaces. Brown suggests using a solution of ¼ teaspoon of bleach in a cup of water.
And when you’re prepping fruits and veggies always rinse with cold water. If the surface is bumpy, then use a brush to get them clean, Brown said.
Monday, March 3, 2014
Roos Cheese Recall Expanded Again
Roos Foods is expanding the recall of their cheese products for the third time. The initial recall was shortly followed by an expansion. And within a week, it has been expanded yet again.
We have seen the 'ever-expanding recall' in the past when there is a Listeria contamination issue. In these cases, company officials failed to understand the extent of the Listeria contamination in their plant and on their products.
Listeria is an environmental contaminate for food processing plants. Without control, or adequate control, it can really spread out across a facility, from floors and drains to processing and packaging equipment. For facilities that manufacturer RTE meat and cheese products, control is essential. Part of a Listeria Control Program for a facility is monitoring. This is done through testing for Listeria in the processing environment.
When facilities have expanding recalls, it is often an indicator that they did not truly understand the extent of the contamination. With a stout environmental testing program, they would have understood the extent of the contamination....well, hopefully they would have seen and corrected the issue long before it got to this point.
It is also important to note that the product this company produced had increased risk factors: 1) they were producing soft cheeses - items more prone to Listeria growth, and 2) they were shipping these products long distances - which may provide more opportunities for temperature abuse and indicates that product has a longer shelf-life, which provides more opportunity for Listeria to grow.
FDA Recall Notice
UPDATE) EXPANDED - Roos Foods Voluntarily Recalls Variety of Cheeses (listed below) Due to Possible Health Risk
Contact:
Consumer:
302-653-0600
FOR IMMEDIATE RELEASE - March 1, 2014 - Update: On February 23 and 25, 2014 Roos Foods issued press releases for the recall of our cheese products. This recall has been expanded to include all product sizes and containers of Santa Rosa de Lima Queso Duro Blando (hard cheese), and Mexicana Queso Cojito Molido. This update also serves as additional clarification that ALL sizes and containers of the cheese products previously identified are being recalled (Amigo, Anita, Mexicana, and Santa Rose de Lima brands of: Cuajada En Terron, Cuajada/Cuajadita Cacer, Cuajada Fresca, Queso Fresco Round, and Queso Duro Viejo (hard cheeses), Requeson, Queso de Huerta and Quesco Fresco. These cheeses were packaged in various sized clear plastic wrapped Styrofoam trays, clear plastic wrapped, clear plastic vacuum package, and clear rigid plastic containers.
Roos Foods of Kenton, DE is voluntarily recalling the above products because they have the potential to be contaminated with Listeria monocytogenes, an organism which can cause serious and sometimes fatal infections in young children, frail or elderly people, and others with weakened immune systems. Although healthy individuals may suffer only short-term symptoms such as high fever, severe headache, stiffness, nausea, abdominal pain and diarrhea, Listeria infection can cause miscarriages and still births among pregnant women.
Out of an abundance of caution, Roos Foods is also recalling all product sizes and containers of Santa Rosa de Lima Crema Salvadorena Cultured Sour Cream, Santa Rosa de Lima Mantequilla de Bolsa Tradicion Centroamericana, Crema Pura Mexicana Cultured Sour Cream, La Chapina Crema Guatemalteca Guatemalan Style Cream, and Amigo Brand Crema Centroamericana Cultured Sour Cream. These sour creams were packaged in various sized white plastic tubs, clear plastic bags, clear plastic pouches, and clear plastic jars.
Products were distributed through retail stores in Delaware, Maryland, New Jersey, New York, Virginia and Washington, DC.
Customers should destroy all lots of the above listed brand named products. If you have any further questions please contact Virginia Mejia phone number 302-653-0600, Monday thru Friday from 9:00 AM to 3:00 PM EST.
Virginia Mejia
Controller
Roos Foods
Kenton, DE 19955
We have seen the 'ever-expanding recall' in the past when there is a Listeria contamination issue. In these cases, company officials failed to understand the extent of the Listeria contamination in their plant and on their products.
Listeria is an environmental contaminate for food processing plants. Without control, or adequate control, it can really spread out across a facility, from floors and drains to processing and packaging equipment. For facilities that manufacturer RTE meat and cheese products, control is essential. Part of a Listeria Control Program for a facility is monitoring. This is done through testing for Listeria in the processing environment.
When facilities have expanding recalls, it is often an indicator that they did not truly understand the extent of the contamination. With a stout environmental testing program, they would have understood the extent of the contamination....well, hopefully they would have seen and corrected the issue long before it got to this point.
It is also important to note that the product this company produced had increased risk factors: 1) they were producing soft cheeses - items more prone to Listeria growth, and 2) they were shipping these products long distances - which may provide more opportunities for temperature abuse and indicates that product has a longer shelf-life, which provides more opportunity for Listeria to grow.
FDA Recall Notice
UPDATE) EXPANDED - Roos Foods Voluntarily Recalls Variety of Cheeses (listed below) Due to Possible Health Risk
Contact:
Consumer:
302-653-0600
FOR IMMEDIATE RELEASE - March 1, 2014 - Update: On February 23 and 25, 2014 Roos Foods issued press releases for the recall of our cheese products. This recall has been expanded to include all product sizes and containers of Santa Rosa de Lima Queso Duro Blando (hard cheese), and Mexicana Queso Cojito Molido. This update also serves as additional clarification that ALL sizes and containers of the cheese products previously identified are being recalled (Amigo, Anita, Mexicana, and Santa Rose de Lima brands of: Cuajada En Terron, Cuajada/Cuajadita Cacer, Cuajada Fresca, Queso Fresco Round, and Queso Duro Viejo (hard cheeses), Requeson, Queso de Huerta and Quesco Fresco. These cheeses were packaged in various sized clear plastic wrapped Styrofoam trays, clear plastic wrapped, clear plastic vacuum package, and clear rigid plastic containers.
Roos Foods of Kenton, DE is voluntarily recalling the above products because they have the potential to be contaminated with Listeria monocytogenes, an organism which can cause serious and sometimes fatal infections in young children, frail or elderly people, and others with weakened immune systems. Although healthy individuals may suffer only short-term symptoms such as high fever, severe headache, stiffness, nausea, abdominal pain and diarrhea, Listeria infection can cause miscarriages and still births among pregnant women.
Out of an abundance of caution, Roos Foods is also recalling all product sizes and containers of Santa Rosa de Lima Crema Salvadorena Cultured Sour Cream, Santa Rosa de Lima Mantequilla de Bolsa Tradicion Centroamericana, Crema Pura Mexicana Cultured Sour Cream, La Chapina Crema Guatemalteca Guatemalan Style Cream, and Amigo Brand Crema Centroamericana Cultured Sour Cream. These sour creams were packaged in various sized white plastic tubs, clear plastic bags, clear plastic pouches, and clear plastic jars.
Products were distributed through retail stores in Delaware, Maryland, New Jersey, New York, Virginia and Washington, DC.
Customers should destroy all lots of the above listed brand named products. If you have any further questions please contact Virginia Mejia phone number 302-653-0600, Monday thru Friday from 9:00 AM to 3:00 PM EST.
Virginia Mejia
Controller
Roos Foods
Kenton, DE 19955
Friday, February 28, 2014
FDA has deadlines set for FSMA rules
We now have some deadlines set for FSMA final rules, with Preventive Controls for food in August of 2015 and Produce in October of 2015. So it will follow, that the deadlines for companies to implement those rules will also be kicked down the road even further.
But this is no reason for companies not to begin the development and implementation of food safety systems based upon best practices.
But this is no reason for companies not to begin the development and implementation of food safety systems based upon best practices.
The Packer
FDA agrees to firm food safety law deadlines
02/26/2014 03:14:00 PM
Tom Karst
The Food and Drug Administration has agreed to deadlines on final food safety rules mandated by the Food Safety Modernization Act.
The consent agreement (http://bit.ly/1o1bc8K), issued by the U.S. District Court in the Northern District of California, appears to be the final chapter on a legal action brought against the FDA by consumer activist groups. The Center for Food Safety and the Center for Environmental Health filed a lawsuit in August 2012 charging that the FDA illegally missed deadlines for food safety rules set by Congress in the 2011 Food Safety Modernization Act.
2012 Norovirus Outbreak in Germany Linked to Imported Frozen Strawberries
A report details the 2012 outbreak of Norovirus in Germany where approximately 11,000 cases were reported. The report concludes that fresh frozen strawberries imported from China were the food vehicle.
Because the fruit is fresh frozen, there are no destructive processes such as heat to remove or reduce Norovirus. Keys to prevention for the grower / packer are having good personal hygiene programs including employee health policies, and systems to maintain potable wash water.
For the broker or the purchaser, supplier control should include ways to ensure that the grower/packer have these programs in place, especially for these minimally processed RTE items. Testing for Norovirus in not commonly done.
Eurosurveillance
Volume 19, Issue 8, 27 February 2014
Surveillance and outbreak reports
Large multistate outbreak of norovirus gastroenteritis associated with frozen strawberries, Germany, 2012
http://www.eurosurveillance.org/ViewArticle.aspx?ArticleId=20719
H Bernard1,2, M Faber (
)1,2, H Wilking 1, S Haller1,3,4, M Höhle1, A Schielke1, T Ducomble1,4,5, C Siffczyk6, S S Merbecks7, G Fricke8, O Hamouda1, K Stark1, D Werber1, on behalf of the Outbreak Investigation Team9
From 20 September through 5 October 2012, the largest recorded food-borne outbreak in Germany occurred. Norovirus was identified as the causative agent. We conducted four analytical epidemiological studies, two case–control studies and two surveys (in total 150 cases) in secondary schools in three different federal states. Overall, 390 institutions in five federal states reported nearly 11,000 cases of gastroenteritis. They were predominantly schools and childcare facilities and were supplied almost exclusively by one large catering company. The analytical epidemiological studies consistently identified dishes containing strawberries as the most likely vehicle, with estimated odds ratios ranging from 2.6 to 45.4. The dishes had been prepared in different regional kitchens of the catering company and were served in the schools two days before the peaks of the respective outbreaks. All affected institutions had received strawberries of one lot, imported frozen from China. The outbreak vehicle was identified within a week, which led to a timely recall and prevented more than half of the lot from reaching the consumer. This outbreak exemplifies the risk of large outbreaks in the era of global food trade. It underlines the importance of timely surveillance and epidemiological outbreak investigations for food safety.
Because the fruit is fresh frozen, there are no destructive processes such as heat to remove or reduce Norovirus. Keys to prevention for the grower / packer are having good personal hygiene programs including employee health policies, and systems to maintain potable wash water.
For the broker or the purchaser, supplier control should include ways to ensure that the grower/packer have these programs in place, especially for these minimally processed RTE items. Testing for Norovirus in not commonly done.
Eurosurveillance
Volume 19, Issue 8, 27 February 2014
Surveillance and outbreak reports
Large multistate outbreak of norovirus gastroenteritis associated with frozen strawberries, Germany, 2012
http://www.eurosurveillance.org/ViewArticle.aspx?ArticleId=20719
H Bernard1,2, M Faber (
)1,2, H Wilking 1, S Haller1,3,4, M Höhle1, A Schielke1, T Ducomble1,4,5, C Siffczyk6, S S Merbecks7, G Fricke8, O Hamouda1, K Stark1, D Werber1, on behalf of the Outbreak Investigation Team9From 20 September through 5 October 2012, the largest recorded food-borne outbreak in Germany occurred. Norovirus was identified as the causative agent. We conducted four analytical epidemiological studies, two case–control studies and two surveys (in total 150 cases) in secondary schools in three different federal states. Overall, 390 institutions in five federal states reported nearly 11,000 cases of gastroenteritis. They were predominantly schools and childcare facilities and were supplied almost exclusively by one large catering company. The analytical epidemiological studies consistently identified dishes containing strawberries as the most likely vehicle, with estimated odds ratios ranging from 2.6 to 45.4. The dishes had been prepared in different regional kitchens of the catering company and were served in the schools two days before the peaks of the respective outbreaks. All affected institutions had received strawberries of one lot, imported frozen from China. The outbreak vehicle was identified within a week, which led to a timely recall and prevented more than half of the lot from reaching the consumer. This outbreak exemplifies the risk of large outbreaks in the era of global food trade. It underlines the importance of timely surveillance and epidemiological outbreak investigations for food safety.
Monday, February 24, 2014
Over addition of vitamin leads to illness associated with rice product
Earlier this February, Uncle Bens Rice product was recalled after there were a number of cases of illness. It appears that the issue was that the product had excessive niacin addition. "The FDA said overexposure to niacin can cause skin reactions, and very large doses can cause indigestion and nausea."
There are a number of chemicals that are added to food that can become hazards if these chemicals are not added in the right concentrations, including vitamins and minerals.
Along with Niacin (Vitamin B3), other vitamins that can be problematic from over addition include Vitamin A, Vitamin B6, and Vitamin E. Certain minerals such as iron and zinc can also be a problem if there is excessive intake.
Over dosage can be a problem with gummy vitamins, where kids treat the vitamins like candy.
For food processing operations who add chemicals such as vitamins and minerals, it is important to include this in the hazard analysis. One needs to evaluate whether a chemical hazard could occur through over addition.
CBS News
Feds warn against eating some Uncle Ben's rice
http://www.cbsnews.com/news/feds-warn-against-eating-some-uncle-bens-rice/
WASHINGTON -- The Food and Drug Administration is warning against eating Uncle Ben's rice products served at schools, restaurants, hospitals and other food service institutions after children in three states had skin reactions and other symptoms that were linked to the rice.
Mars Foodservices, of Rancho Dominguez, Calif., is recalling 5- and 25-pound bags of the rice. The bags are mostly sold to food service establishments, but they are also available to consumers over the Internet and in some warehouse-type retailers.
Uncle Ben's ready-to-eat, boxed, bagged and cup products in grocery stores are not linked to the illnesses and have not been recalled.
The FDA said 34 students and four teachers in Katy, Texas, had experienced burning, itching rashes, headaches and nausea for 30 to 90 minutes after eating the rice on Feb. 6. The symptoms eventually went away.
The agency said it is still investigating the Texas incident. But FDA officials said they found an excess of niacin, also known as vitamin B3, in Uncle Ben's food service rice linked to similar reactions in 25 Illinois school children in December. That incident also prompted a recall, but the Texas illnesses were not related to those previously recalled lots.
The FDA said overexposure to niacin can cause skin reactions, and very large doses can cause indigestion and nausea. Children may be most susceptible, but the agency said the levels of niacin found in the Illinois rice samples probably were not high enough to cause serious health consequences.
There are a number of chemicals that are added to food that can become hazards if these chemicals are not added in the right concentrations, including vitamins and minerals.
Along with Niacin (Vitamin B3), other vitamins that can be problematic from over addition include Vitamin A, Vitamin B6, and Vitamin E. Certain minerals such as iron and zinc can also be a problem if there is excessive intake.
Over dosage can be a problem with gummy vitamins, where kids treat the vitamins like candy.
For food processing operations who add chemicals such as vitamins and minerals, it is important to include this in the hazard analysis. One needs to evaluate whether a chemical hazard could occur through over addition.
CBS News
Feds warn against eating some Uncle Ben's rice
http://www.cbsnews.com/news/feds-warn-against-eating-some-uncle-bens-rice/
WASHINGTON -- The Food and Drug Administration is warning against eating Uncle Ben's rice products served at schools, restaurants, hospitals and other food service institutions after children in three states had skin reactions and other symptoms that were linked to the rice.
Mars Foodservices, of Rancho Dominguez, Calif., is recalling 5- and 25-pound bags of the rice. The bags are mostly sold to food service establishments, but they are also available to consumers over the Internet and in some warehouse-type retailers.
Uncle Ben's ready-to-eat, boxed, bagged and cup products in grocery stores are not linked to the illnesses and have not been recalled.
The FDA said 34 students and four teachers in Katy, Texas, had experienced burning, itching rashes, headaches and nausea for 30 to 90 minutes after eating the rice on Feb. 6. The symptoms eventually went away.
The agency said it is still investigating the Texas incident. But FDA officials said they found an excess of niacin, also known as vitamin B3, in Uncle Ben's food service rice linked to similar reactions in 25 Illinois school children in December. That incident also prompted a recall, but the Texas illnesses were not related to those previously recalled lots.
The FDA said overexposure to niacin can cause skin reactions, and very large doses can cause indigestion and nausea. Children may be most susceptible, but the agency said the levels of niacin found in the Illinois rice samples probably were not high enough to cause serious health consequences.
Subscribe to:
Posts (Atom)